Greenworks manufacturers one of the most popular battery powered lawn mowers on the market today.
Always remove the battery before making any repairs to the electrical system. let the $125 battery go completely dead or I will kill it. The popularity also means that more than one person has likely faced the mower issue that you are up against. Wear eye and head protection when operating this equipment. For your safety and the safety of others, never operate your mower without all of the safety switches in working order. What can be done to fix this. If your lawn grows at exactly the same pace then this is not an issue, but that is the exception and not the rule when it comes to turf.
Battery is low in charge. It started then 5 sec. Not only are these components usually pricy, but they are best handled by individuals with extensive mechanical and electrical knowledge who can safely remove the damaged parts and reinstall new ones. You may find it on the battery, on the mowers indicator panel or you may have to place your battery on the charger to read the charging status.
To reduce overloading the engine, avoid cutting wet grass and raise the cutting height when cutting thick or tall grass. You can test each switch by temporarily bypassing them with a jumper wire. put the battery in the charger. Stop the motor and wait until the blade comes to a complete stop before removing the grass catcher or unclogging the chute. There is some slack, but that would keep it from starting. If you discover that either of these pieces is damaged and likely the cause behind your lawn mower not starting, youre probably better off taking your Greenworks lawn mower to a professional repair shop instead of fixing it yourself. OPERATING YOUR LAWN MOWER EMPTYING THE GRASS CATCHER BAG (See Figure 9) Stop mower, allow blades to completely stop, and remove key. Also, check with Greenworks if you are still covered by its manufacturer warranty. MAINTENANCE REPLACING THE BATTERY The mower battery is designed for maximum life; however, like all batteries, it will eventually need to be replaced. When you make purchases through these links, we may earn a small commission.
Insert your battery into the charger making sure the contacts on the battery pack engage with the charger and is securely in place.
ASSEMBLY INSTRUCTIONS TO INSTALL BATTERY PACK (See Figure 5) Lift and hold up the battery door. When your Greenworks battery isnt giving you good power, your lawn mower wont start. SYMBOL SIGNAL MEANING DANGER Indicates an imminently hazardous situation, which, if not avoided, will result in death or serious injury. If the machine is not going to be used immediately, do not insert the key.
You may find your mower battery lasts as it should, but there seems to be many owners that report batteries that dont last long enough. This along with slowing down while mowing will decrease the load put on your Greenworks lawn mower.
SAFETY INFORMATION For battery pack storage longer than 30 days: Store the battery pack where the temperature is below 80F and away from moisture. Is there any way to resuscitate to battery? Make certain the handles snap into place securely. Many pieces need to be replaced routinely and come at a minimal cost, but the most problematic pieces might cost you more than the lawn mower is worth after purchasing the replacement and any professional help required to fix it.
Check the connection between the motor connector and the battery.
You will most likely have lights on the battery that indicate the level of the battery charge. Please answer.
You can adjust them, but it seems like there should be a better system that does not involve adjusting metal wires. After mowing a while, one of the leds goes on. Save this manual for future reference. Log in, https://greenworks.ordertree.com/dealerlocator, Best Corded Electric Lawn Mower Reviews for 2019, Best Cordless Lawn Mowers: 2019 Reviews & Buying Guide, Best Push Lawn Mower Reviews Guide For 2018, Troubleshoot and Resolve Greenworks Lawn Mower Problems. How can I shorten the handle on my mower. Even with the mower not engaged to the ground. PARTS LIST ITEM NO. Now I cant get it to run more than 5 seconds.
Please study them and learn their meaning. SERVICE When ser vicing the mower, use only replacement par ts that are available from the manufacturer. SAFETY INFORMATION Stop the blade when crossing gravel driveways, walkways, or roads. Proper interpretation of these symbols will allow you to operate the product better and safer.
Some of these wires may develop a short because they become loose or pinched. The mower will shut off when you release the safety bar. There are many electrical wires running through your lawn mower.
I left it covered all winter and today was the first time I used it in 2022. There is a fix for this problem if you are up to the task. Another sign your battery is going bad is when it becomes very hot.
You can do this with a pair of pliers. It takes about 6 Amp hours to mow my lawn, depending on how long it is. 6) Pull the bail switch (2) upward to the handle to start the mower and release the button. Hedge Trimmer Buyers Guide, Handy Lawn Garden Tools You Cannot Live Without, In-depth Review: Poulan Pro 961420127 Self Propelled 22 inch Mower, Toro 20383 Super Recycler Lawn Mower Review, Husqvarna HU700H (961450023) Rear Wheel Drive Mower Review, One of the Best Self Propelled Lawn Mowers: The Lawn Boy 10734 Review, Husqvarna Self Propelled Lawn Mower HU725AWD/BBC, Old School Snapper Rear Engine Riding Mowers, Toro Timecutter SS5000 Zero Turn Mower Review, Why Everybody Should Have an Electric Lawn Mower. So much for the double protection of the cable and button. I have the same problem. You can use a standard 120V outlet. When mowing normal or thinner grass, the mower will idle down a bit. Compare the illustration in Figure 1 to your lawn mower in order to familiarize yourself with the location of various controls and adjustments. SYMBOLS Some of the following symbols may be used on this product.
Become familiar with all controls and their proper operation. Vibration is generally a warning of trouble. 
At its lowest but dos not reach low enough to cut grass it needs to come down at least an inch or more how Cani lower it past the handle range, My mower starts as soon as the battery is put in. Remove battery; check under deck for jams. Keep reading for additional causes to your starting problem. OPERATING YOUR LAWN MOWER STARTING/STOPPING THE MOWER (See Figure 5-6) To start the motor: Open the battery door and insert the key into the slot. This feature sounds like a good idea.until you lose power in thick grass which bogs down the machine. ASSEMBLY INSTRUCTIONS INSTALLING THE GRASS CATCHER BAG (See Figure 3) Lift the chute cover (1). I have had to sharpen blades on a brand new mower before ever using it once!
No gas to get old and gum up the system. But died just as I was finishing. Lets have a look at some mechanical problems that are specific to GreenWorks lawn mowers. As an Amazon Associate we earn from qualifying purchases. Do not charge the battery in a wet location. POSSIBLE CAUSE SOLUTION The battery is not charged.
Mower cutting grass Lawn is rough or uneven or, Mower not mulching Wet grass clippings sticking to, Mower hard to push. OPERATING YOUR LAWN MOWER SLOPE GAUGE (See Figure 8) WA R N I N G Slopes are a major factor related to accidents involving slips and falls, which can result in severe injury. Just because you purchased a good mower doesnt mean it will be problem free. Save my name, email, and website in this browser for the next time I comment. Lift the rear chute cover and reinstall the grass catcher bag as described earlier in this manual. Replace any bad switch. Before cleaning, repairing, or inspecting, verify that the blade and all moving parts have come to a complete stop, and remove the key. Insert the key. Set height higher and pass over area twice, 19" cordless hand push lawn mower (36 pages), 19" cordless self-propelled lawn mower (36 pages), 19 40 v lithium-ion cordless mower (35 pages), 19 40 v lithium-ion cordless mower (2 pages), 40 v lithium-ion dual blade mower greenworks REMOVE BATTERY. Consult a professional if you dont have the skills, knowledge or are not in the condition to perform the repair safely. Mow across the face of a slope, and never up and down. 6 40 V Lithium-Ion Cordless Mower 25322 Owners Manual TOLL-FREE HELPLINE: 1-888-90WORKS (888.909.6757) www.GreenWorksTools.com Read all safety rules and instructions carefully before operating this tool. If any parts are damaged or missing, please call 1-888-909-6757 for assistance.
A Greenworks lawn mower wont start when it doesnt have sufficient battery power due to using the wrong size battery, incorrect battery installation, a dead battery or one that will no longer hold a charge. CONTENTS Contents. 2 Product specifications.. 2 Safety information.. 3-7 Symbols SAFETY INFORMATION GENERAL SAFETY RULES READ ALL INSTRUCTIONS CAREFULLY WA R N I N G This symbol indicates important safety instructions. My brand new 80v wont switch from one battery to the other as it should. Read my article on the dangers of electric mowers so you understand why you need to take caution when working on your electric mower. Lift the grass catcher bag by its handle to remove from mower. Cables have always been a headache on mowers. SYMBOL DESIGNATION/EXPLANATION V Volts A Amperes Hz Hertz W Watts Hrs Hours Precautions that involve your safety. Also switch to a side chute instead of mulching for thicker grass. When installed correctly, the hooks on the grass catcher will rest securely in the slots on the handle brackets. Hopefully, your Greenworks mowers starting troubleshooting doesnt come to this point, but if it does, you might have a pricy solution on your hands. Wash those and it should work fine. Charge the battery. If these instructions are not followed, it could endanger the personal safety and/or property of the operator and others. The internet may have a dark side, but the benefits are numerous thanks to the collective brain that can solve some issues, whether they are lawn mower related or not. Can anything be done to correct this.
Check underneath the deck and scrape any debris that has collected. Simple machines are easier to work on and that is a staple of this companys design process. This issue prevents the mower from starting up as it should. Well, it does protect the user since you cant get hurt with a mower that wont start! Overloading the engine due to a plugged mower deck can stop your mower and prevent it from starting.
Align guided ribs on battery pack with grooves in the products battery port. Do not place battery tools or their batteries near fire or heat.
Just make a bend in the cable carefully to remove any slack. CHARGER SAFETY RULES Charge the mower battery in a dry area that is protected from the weather. Install the new battery pack. SAFETY INFORMATION Carefully read all instructions on the mower and in the manual before attempting to assemble and operate the mower. 2 Fig. Check the cable to see if it is too loose. MAINTENANCE REPLACING THE CUTTING BLADE (See Figure 10-11) WA R N I N G Always protect your hands by wearing heavy gloves and/or wrapping the cutting edges with rags or other materials when performing any maintenance on the blades. Wait until the grass dries before mowing. Know how to stop the mower and how to disengage the power in an emergency. You can tell your battery is going bad when you fully charge the battery and it is no longer holding a charge as long as it once did. Do not attempt to modify the plug. The batteries show full power. These issues can be troublesome since electric mowers are fairly new on the scene when it comes to mainstream use.
Place battery in and go. Carefully unlock and remove the battery pack. These machines have pleased everyone from accountants mowing their own lawns to teenagers trying to make some extra cash for the movies. Operating the mower on a slope requires extra caution. Following this rule will reduce the risk of electric shock, fire, or serious personal injury. The mulching plug must be re-installed when the grass catcher bag is removed. If the mower starts to vibrate excessively, stop the motor and check for the cause immediately. Electric mowers have different issues. WA R N I N G Toxic materials must be disposed of in a specified manner in order to prevent contamination of the environment.
Tighten the lower handle with the cam locks on both sides. Now it either wont start at all or starts then dies in 5 secs. As a reminder, always remove your battery before working on the deck. You may be able to check the level of charge on the battery for some models using an LED lighting system.
I looked online and found I should NEVER! (See Fig. GREENWORKS, at its own discretion will repair or replace any and all parts found to be defective, through normal use, free of charge to the customer.
TROUBLESHOOTING PROBLEM The mower does not start.
The mulching plug (3) is inserted on an angle, so it requires some force to remove it. 
Im not sure if these manufacturers are just playing a prank on us or it is a safety thing. Before disposing of damaged or worn out Lithium-Ion battery packs, contact your local waste disposal agency for information and specific instructions. 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 PART NO. Grasp the handle (2) of the mulching plug and pull the mulching plug out using the handle. Everything else works great but after researching the motor problem, I found the brush are done. Mower starts up, battery fully charged, but then the motor cuts out after about 5m seconds.
- Black Long Sleeve Shirt Women's Near Me
- Lorac Pro Matte Lip Color Pink Taupe
- Estate Auctions Delaware
- Aluminum Truck Loading Ramps
- Image Adapter Android Studio
- Magnetic Measuring Spoons Set
- Astir Beach All Inclusive
- Photochromic Lenses Vs Blue Light Lenses
- The Evans Group Real Estate
- Cordless Vacuum With Soft Roller